100K (km) Maintenance!

Hey,

I have a couple of questions. I just hit 101,543KM on my 2006 Chevrolet Aveo5 Special Value. I bought the car at 70,000KM and I'm not sure what was done before it was sold to me.. I know it was a lease return though. I've already replaced the sepertine belt - 3 times, a front driver side control arm bushing and ball joint and now I'm looking at a driver side wheel bearing and brake pads.

1) Could I put off the timing belt until I have the money? It's around $200 to get done, but I don't have the money and can't have it lended but I should have it in 2-3 weeks.. Trying to get a job. The question is, if it started slipping or wearing would it give warning signs?

2) I need a new windshield, it's got a big crack but it's still stable, not worrying about it shattering. how much am I looking at for this?

3) I have a minor fender dent/crease in the front driver side fender, what tool do I need to take off the fender cover? Is there any chance I could pop out the dent/crease?

5) I find when my clutch is fully pressed in it's under 1,000RPM. What's happening here? It doesn't do the little 'jerk' so to speak when you shift anymore, but it goes into gear fine and once I let out the clutch it engages fine. It has a really smooth steady acceleration and feel to it.

4) Any other maintance I should have done when I get the money? Right now my list is:

- Timing belt
- Wheel bearing
- Brake pads
- Oil change
- Windshield

I think the ball joint, control arm and now bearings are all related. One failed first and killed the other two.

#5 not only doesn't make sense, it's in the wrong place. Timing belt should come before windshield and fender dent, you'll need to check local prices on the windshield though it varies greatly.

The water pump Should be done with the timing belt, along with doing the tensioner.

re: #2 - shop around different glass places for the windshield quote. I got a crack in one of my Rabbit's windshields years ago and after calling a few places discovered one that was willing to pay my insurance deductable to get the job.

I agree with Rabbit, get that timing belt done. Is the 200 dollar cost include parts and labor. If so go for it as that is dirt cheap. I spent just 120 for the Car Quest Kit that included belt and rollers. I installed the timing belt myself at 72,000 miles. It was tedious but not hard.

Quote:

---

I've already replaced the sepertine belt - 3 times

---

Why did you replace the serpentine belt three times? I had my car quest belt on it for 80K miles with no problems. I too have a Special Value 2006 with the Dealer Installed AC. I bought my used from a dealer with only 5K on it. So Yeah Special Value Aveos! The Cheapest of the Cheap!

The Special Values are just as nice... As for the belt, the first one went when I drifted in a loose gravel parking lot. I'm guessing gravel hit the belt and knocked it out of it's place and caused the wear/tear without my noticing. The second belt was Canadian Tire's fault, they moved my power steering hose for some reason and it chafed not only the hose but the belt, the third belt however I have no idea what happened.

As for the timing belt, that was including parts and labor. It's $200, but I can't borrow the money. Could I put it off long enough to get a pay check? I'm at about 102,000KM. It's not slipping any that I can notice. It's at the top of my list if you look above, just not the first question.

Quote:

---

It's not slipping any that I can notice.

---

FYI, the timing belt is cogged - it won't slip. (A cogged belt could potentially "jump", but if it did the car would probably not run - or run really, really badly.)

When a cogged belt is toast, it generally snaps. Then some nasty, expensive stuff happens inside an interference engine. :)

Some people are comfortable inspecting their belts for visual signs of weakness (cracked/hazed rubber) to decide whether to change it or not. Personally, I wouldn't risk it, knowing the history of belts on this engine.

So you don't think I'd be okay just for about 2 weeks with minimal driving? Otherwise it's sitting in the yard, and I'll have no way to town, the girlfriends, work e.t.c - Unless I was driven, in another vehicle.

Oh, I mean 2 weeks is probably OK. It doesn't sound like you're looking for an excuse not to do it :)

I'm not, I actually really wanna do it but I honestly don't have the money and my folks won't lend it to me, already asked. So I'm trying to find a job, then it might not even be 2 weeks time just whenever the next pay checks go out from the day I start.. Hopefully it's less then 2 weeks, first thing the money is going to is getting the belt changed. It'll be a load off my shoulders.

I'm still in high-school, and owe my folks around $4,000 still on the car. So I'm having a hard time keeping up with repairs, and gas. To top it all off, I got laid off the job I had before Christmas. I got a lot of work to do.

101,543KM is 63095 statue miles. I think the service is scheduled at 70K miles. I don't have my manual in front of me. Others will know better than me. It's a risk*, I say wait until you get your pay check. Just remember if you replace the water pump at the same time your cost can jump significantly. The water pump is used to adjust the tension on the timing belt. I personally did not replace my seals or water pump when I changed my timing belt.

*Cars suck (they suck cash) can you ride a bike to work? Never mind you live in Canada and could be ridding in 2 feet of snow. If you wait try alternate methods of getting to work to reduce the mileage on your aveo.

So I should be good until 70,000 miles? I won't reach that before I have the money. However, I live 45 minutes away from school, work, and everywhere else. I live in Cavendish, PEI. Go to school in Cornwall, PEI and hopefully working in either Charlottetown or Summerside.

That's the problem... The distance. I don't live by any friends or anything, so not only am I alone. I can't get a drive anywhere.

Quote:

---

Originally Posted by brendan_m09

\
I'm still in high-school, and owe my folks around $4,000 still on the car. So I'm having a hard time keeping up with repairs, and gas. To top it all off, I got laid off the job I had before Christmas. I got a lot of work to do.

---

did you tell your parents, that a $4000 loan for a car is a worthwhile investment, but if the timing belt breaks, they own a $4000 lawn ornament? (because they obviously wont give you $1000 or so it would cost to fix it then)

if they argue with you, it because its used, i've let my wife make the same mistake. she bought a v6 audi with 79k miles. About a month after, i read about the timing belt needing done at 80k, all the accessories run of the timing belt on that model. The dealership wanted $3600 to do it, and replace the known failing pieces (ie waterpump, 2 idler pulleys, a tensioner, etc.) I was going to do it myself but discovered a highly recommended tool for keeping the 4 cams in line was $500.. so i priced out all the parts, and found a shop that did it for the $500 labor.. and the car needed a power steering pump.

she bought the car with 79k for $2000 MORE than one with 90k (same car) that had this service done.. so she learned a $4000 lesson about reading abut service intervals when looking at used cars, because the original owners all seem to get rid of the cars right before its due..

I already mentioned it to them, now they're talking about selling it before I turn it into a lawn ornament. So basically I have no other option.

But if it's not supposed to get it done until 70,000 miles I should be fine, right?

Mine let go at 67,719 miles and bent 8 valves. The suggested timing belt change interval is 60,000 miles. Don't push it.

well reviving a 1 year old thread cause 200.00 is unbelievable CHEAP!!!!! hope you got the belt done and dont own a lawn ornimate.around here southern ontario a good price is 120 tbelt,80 waterpump + 6-hrs labour = 500-800 canadian dollars :-0